 |
In this week's episode of Kitchen Renovations, host Paul Ryan will assist the homeowners in converting this antiquated kitchen ...
|
| |
into this kitchen that would be any chef's delight, ...
|
| |
with top-of-the-line, professional-style appliances!
|
| |
In this final episode of "Chef's Kitchen," the renovation is completed, starting with laying the Terrazzo tile, seen here, on the floor.
|
|
In the first segment of Pt. 4 of "Chef's Kitchen," host Paul Ryan recaps the progress made thus far in the chef's kitchen and then teams up with the homeowners to dot he final prep work on the subfloor. They then determine the reference points to make the layout of the floor visually appealing.Materials: Preparing the Subfloor -- Putty knife
Hammer
Skim coat Laying the Terrazzo Tile -- Tape measure
Pencil
Chalk line
Hairspray
Terrazzo tiles
Marker
Diamond edge wet saw
Wet-set adhesive
1/16" square-notch trowel
150 lb. roller Installing Glass Insert -- Silicone glazing bead
Putty knife Installing Slate Insert -- Silicone
Hot glue gun
Hardwood lathe Installing Window Insert -- Drill
Spade bit
Jigsaw
Shims
Screw gun
Prepping the Subfloor for Terrazzo Tile- Make sure the staples are pounded down, and check to make sure by running a 5" or 6" putty knife over the floor.
- Mix a small batch of skim coat according to directions on the package.
- Using a straight-edge trowel spread a very thin layer of skim coat over the seams (figure A).
- Once it's almost dry, scrape the excess off the edges.
- Sweep and vacuum.
Measuring for Tile Installation- Determine the longest run of the kitchen, and for this particular project it's from the hallway to the back door.
- Measure from the outside wall to the center of this run -- and make a mark (figure B).
- Go farther down the wall and make another mark the same distance out from the wall.
- Use these marks to snap a line the full run of the room, and this line should be parallel to the outside wall. This line will be your reference mark to begin tiling.
- Spray the chalk line with hair spray to set the line (figure C).
- Dry fit the tiles (figure D) to the outside wall to determine where the first row of full tiles will be. Make a mark, transfer this same measurement down the wall and make another mark.
- Snap a line using these two marks.
In the next segment, Ryan and the homeowners install the tile.
RESOURCES :
Skil
Robert Bosch Tool Corp.
Website: www.skiltools.com
Stanley Tools Information
Stanley Tools/Works
Website: www.stanleyworks.com
Fiskars (Bucket Boss Division)
Fiskars Bucket Boss Division
Website: www.bucketboss.com
Makita Products
Makita USA Inc.
Website: www.makita.com
Paslode Nail Guns
Paslode
Website: www.paslode.com
3M Painter's Masking Tape and Sanding Pad
The 3M Company
Website: www.3m.com
Paint (Behr)
The Home Depot
Website: www.homedepot.com
Spray Paint (Rust-Oleum)
Rust-Oleum Corp.
Website: www.rustoleum.com
Terrazo Tile (Fritz Industries)
Brand name: Fritz Tile
Model #: GT3098
Color: Grainite
Where available: Visit the Fritz Industries website, link below.
Fritz Industries
500 Sam Houston Rd.
Mesquite, TX 75149
Toll-free: 800-955-1323
Website: www.fritztile.com
Integral Blinds (ODL)
Brand name: ODL
Model #: 684-RLB
Color: White
Where available: Nationwide at lumberyards and home centers or visit the ODL website, link below.
ODL Incorporated
Website: www.odl.com
Prefinished Molding (SpecTrim)
Brand name: SpecTrim
Prefinished Base Molding
Model #: TCB-452-17-10
Color: #17 Natural Cherry
Prefinished Shoe Molding
Model #: TCQ-710-17-10
Color: #17 Natural Cherry
Where available: Visit the SpecTrim website, link below.
SpecTrim Building Products, LLC
PO Box 826
Ben Salem, PA 19020
Toll-free: 800-437-0557
Fax: 215-245-8704
Website: www.spectrimbp.com
Kitchen Faucet (Dornbracht USA)
Brand name: Dornbracht Meta 02
Model #: 32.885.625.06
Color: Platinum Matte
Where available: Visit the Dornbracht website, link below.
Dornbracht USA
1700 Executive Dr., S
Suite 600
Duluth, GA 30096
Toll-free Phone: 800-774-1181
Toll-free Fax: 800-899-8527
Website: www.dornbracht.com
Range, Refrigerator, Vent Hood and Dishwasher
36" Range with Four Burners and Charbroiler
Brand name: Wolf
Model #: R364C
Color: Stainless Steel
42" Refrigerator
Brand name: Sub-Zero
Model #: 680SS
Color: Stainless Steel
Vent Hood
Brand name: Independent
Model #: 42SS 600 CFM
Color: Stainless Steel
Dishwasher
Brand name: Asko
Model #: D3250HDSS
Color: Stainless Steel
Prep Cart, Pot Rack, Cucina Stool and Cutting Board
Rolling Prep Cart
Brand name: Boos Block
Model #: ET3S01
Color: Natural
Rustic Pot Rack
Brand name: Boos Block
Model #: CU-RPR
Color: Natural
Cucina Stool
Brand name: Cucina Americana
Model #: CUCCSTL24
Color: Natural
Cutting Board
Brand name: Boos Block
Model #: RO2
Color: Natural
Where available: Nationwide or visit the John Boos website, line below -- the cutting board is available at Williams-Sonoma or SurLaTable.
John Boos & Co.
Website: www.johnboos.com
Undercounter Climate Controlled Wine Cellar
Brand name: Marvel Wine Grotto
Model #: 61WC-BS-G
Color: Black with stainless framed glass door
Where available: Visit he Marvel Industries website, link below.
Marvel Industries
PO Box 997
Richmond, IN 47375
Toll-free: 800-428-6644
Fax: 765-962-2493
Website: www.marvelindustries.com
Espresso Machine and Accessories
Brand name for all: Pasquine
Espresso Machine
Model: Livia Automatic
Color: Stainless Steel
Coffee Grinder
Model: Moka Grinder with Doser
Color: Stainless Steel
Base (two drawers)
Model: Espresso Machine and Grinder Base
Color: Stainless Steel
Steaming Pitcher
Model: 1/2 Liter
Color: Stainless Steel
Where available: Visit the Pasquini Espresso website, link below, for a list of distributors and dealers.
Pasquini Espresso Co.
Website: www.pasquini.com
GUESTS :
Shane Kretsinger
Vice President, Operations
Autumn River
We apologize no contact information is available.
| 
![PHOTO](javascript:popup("http://img.diynetwork.com/DIY/2004/02/27/dktn210_1ca_e.jpg",350,450))
![PHOTO](javascript:popup("http://img.diynetwork.com/DIY/2004/02/27/dktn210_1cb_e.jpg",350,450))
![PHOTO](javascript:popup("http://img.diynetwork.com/DIY/2004/02/27/dktn210_1cc_e.jpg",350,450))
![PHOTO](javascript:popup("http://img.diynetwork.com/DIY/2004/03/18/dktn213_1ca_e.jpg",350,450))
![PHOTO](javascript:popup("http://img.diynetwork.com/DIY/2004/03/18/dktn213_1fa_e.jpg",350,450))
)
)
)
